RV Roof Repair, Resealing & Roof Coating
Water stain on the ceiling, cracked sealant, or a roof that has not been looked at in years? We find where it is actually getting in and seal it properly.
Call Us · 832-334-1579Sound familiar?
These are the symptoms our customers call about. Elite Reliability RV finds the cause behind each one.
How we approach this
Every expensive RV repair we do started as a roof leak somebody could not see. Water gets in around a vent, a skylight, an antenna, or an AC gasket, runs along the framing, and shows up as a stain, a soft floor, or a rotted slide out a year or two later, nowhere near where it actually entered. That is why we do not just smear sealant over the spot under the stain. We go up top, inspect every penetration and the full perimeter, and trace where the water is really getting in. Then we cut out the failed sealant, prep the surface, and reseal with material that is right for your roof type, whether that is EPDM, TPO, or fiberglass. Getting the material wrong is why so many roof repairs fail in a season.
What we fix
Finding the Actual Leak
Water travels. The stain on your ceiling is almost never under the hole. We inspect every roof penetration and the full perimeter seam so the repair happens where the water is getting in, not where it is showing up.
Resealing Vents, Skylights & Penetrations
Old sealant goes chalky, shrinks, and cracks, and that is where most RV leaks start. We remove the failed material down to a clean surface instead of caulking over it, then reseal with the right product for the roof.
Roof Coating
A full roof coating buys years on a roof that is aged but still sound. It only works on a properly prepped surface, so we inspect and repair first. Coating over a bad seam just hides the problem for a season.
Soft Roof & Structural Repair
If the decking has gone soft, sealant will not fix it. We open it up, cut back to solid material, rebuild the structure, and close it in. Same approach we take with slide out floors.
Water Damage Underneath
A roof leak that has been running for a while usually did damage on its way down. Once the roof is sealed we check the framing, the walls, and the floor so you are not sealing the roof over rot that keeps spreading.
A diagnosis.
Sealing a roof is a materials problem more than a labor problem. EPDM, TPO, and fiberglass each need different products, different prep, and different expectations for how long the repair lasts, and putting the wrong sealant on the right roof fails inside a year. Elite Reliability RV was founded by an engineer with nearly 20 years in oil and gas, and knowing which material goes where is exactly the kind of thing that background is good for.
Frequently asked questions
Ceiling or cabinet stains, a musty smell after rain, soft spots overhead or underfoot, and bubbling in the sidewalls are the common signs. By the time any of those show up the water has usually been getting in for a while, which is why an annual roof inspection is worth doing even when nothing looks wrong.
Inspect the sealant every six months and plan on resealing penetrations roughly every one to two years, sooner in Texas because the heat and UV are hard on it. A full roof coating is more like a every several years job depending on the roof and how it has been kept.
Yes. Roof work is one of the easier jobs to do mobile, as long as there is safe access and the weather cooperates. We come to your driveway, storage lot, or campsite in The Woodlands, Conroe, Magnolia, Spring, Montgomery, and Tomball.
A coating works when the roof membrane and the decking underneath are still sound and the problem is age and small seam failures. If the decking is soft or the membrane is torn or separating, a coating just covers it. We will go up, look, and tell you which situation you are in.
That is the normal case, and yes. Water runs along framing before it drops, so the entry point is often several feet away from the stain. We inspect every penetration and seam on the roof rather than guessing at the spot underneath.
Other work we do
Most RV problems do not stay in one system. If what you are dealing with is not on this page, it is probably on one of these.
RV Electrical Diagnostics & Repair
Breakers tripping, batteries dying overnight, or lights acting up? We diagnose 12V and 120V systems and fix what's actually causing the problem.
RV Air Conditioning Repair & Install
AC not keeping up in a Texas August? We diagnose the whole system, service what can be saved, and replace or upgrade the unit when it is done.
Plumbing & Water System Repair
Fresh water or waste water issue you can't track down? Low pressure, a hidden leak, or a system that won't hold? We check the full system and fix the real problem.
Slide Out & Structural Repair
Slide out floor gone soft or rotted through? Slide won't move? We rebuild slide out floors down to solid framing and fix what caused it.
Custom Builds
Want your RV to look different on the inside? We build custom dinettes, seating, and storage designed for your RV.
Horse Trailer 12V Rewire
Lights working sometimes, burnt smell, or dead outlets in your horse trailer? Elite Reliability RV does complete 12V rewires the right way.
Preventative Maintenance & Inspections
Pre purchase inspections, generator service, oil changes, refrigerators, solar, leveling, windows, and the odd jobs nobody else wants. One tech for the whole RV.
Where we do this work
We are fully mobile, so we bring this service to you. These are the areas we cover most.
Need a hand with your RV?
Call us and tell us what's going on. We come to you.
Call Us · 832-334-1579Serving The Woodlands, Conroe, Magnolia, Spring, Montgomery, and Tomball. We come to you.